If this is your first visit, be sure to
check out the FAQ by clicking the
link above. You may have to register
before you can post: click the register link above to proceed, registering will remove the in post advertisements. To start viewing messages,
select the forum that you want to visit from the selection below.
No idea how far away the dealership is but if no one is getting back to you. Then get down there in person. They won't shut down the place to avoid you. Tell them when you'll be in and that you would like to have some answers.
Well the car is back in my garage now and I had to pay out for the repair myself. Birmingham VW here in the UK refused to cover the repair under warranty and also refused to blame the remap either so I was left asking myself who was actually to blame!
Needless to say I would advise anyone here in the UK to keep away from any remap service offered at ECU Remapping Audi VW BMW Seat Skoda Remap Chip Tuning in Crewe, UK and never do business with Jason Copeland (MD of more-bhp). His refusal to accept any blame for the engine damage and constant deflection of blame onto myself for asking him to remap my car has been disgusting.
I was told he would provide me with a decent solution to prolong the lifetime of the components on my car but the big end failed after only 70 miles of driving. I would say that is clear cut evidence that the remap caused this major failure! Jason Copeland remapped my car to 191bhp when I clearly asked him to give me a reliable option. A previous customer and friend of mine was advised to go for the 170bhp option to prolong his car life but I feel that the 140 CR engine simply couldn't take as much as 191bhp without failing. This condradicted what I was told.
I would advise people to stick to companies like Revo if they care about their car and stay away from cowboys like more-bhp who have caused me nothing but stress - both physical and emotional!
2011 Candy White Tiguan R Line 170 TDI DSG | Pan roof | Park assist & RVC | RNS 510 | MDI | LED's | 20" RS5 Wheels| Bi-xenons & AFS | Front & Rear footwell lights | Door warning & puddle lights | Mirror puddle lights | LED Tail lamps | Eibach Pro-Kit Springs
This sounds all too familiar I've gone through a similar thing in regards to a mechatronics unit failure which is documented all over the world as being a very suspect component. I've recently been informed that my court application has been accepted but a date is "indefinitely suspended" or some crap because if the sheer amount of cases. Good to see the mother f**kers have the same bulltish attitude all over the world.
I'd be investigating your legal rights because in case you didn't know, if you take Vw to court over there it is they who have to prove their claim for warranty refusal. Here, it's the opposite. We have to prove that there is grounds for them to warrant the repair.
Im still a little baffled by this whole scenario. To the OP, i feel for you in regards to what you have been through, but im still not convinced this was caused by the tune. I believe there was a problem with the motor already, and the remap finished it off.
Regardless, thats all in the past now and nothing can be done to take it back. Lets hope this new engine lives a much longer life. I'll take a stab and assume you are no longer interested in trying to tune it?
Im still a little baffled by this whole scenario. To the OP, i feel for you in regards to what you have been through, but im still not convinced this was caused by the tune. I believe there was a problem with the motor already, and the remap finished it off.
Regardless, thats all in the past now and nothing can be done to take it back. Lets hope this new engine lives a much longer life. I'll take a stab and assume you are no longer interested in trying to tune it?
Who would be so brave to try that? When it's unknown how well they've patched up his engine, I deliberately say patched up because from what was posted in this thread, it doesn't look like that the dealer was very transparent.
Giving the history of that engine, I wouldn’t be interested to put any tune on it, only a very desperate tuner would touch it without a signed document that all the responsibility is with the owner of the car.
Just so everyone is clear about the situation, (because there is some pretty slanderous stuff in this thread), here is our version of events following the remap which we carried out on the Tiguan...
Initially we were shocked to find out that number 4 big end bearing had failed on Naresh's car, so we started our own investigations. The exact remapping file used was sent to two independent remapping companies (who actually make their own software), who said that the remap was acceptable and could not have caused damage.
We then employed a highly regarded Independent Auto Engineer (who has done this sort of thing most of his life) to go and inspect the engine at VW, ascertain why the engine failed and produce a report stating his findings.
His conclusions state that number 4 big end bearing suffered from a momentary lack of lubrication, and the bearing shell spun inside the con rod. Because number 4 bearing is the furthest away from the oil pump, it is likely that the engine had been starved of oil OR driven before the oil pressure had reached an adequate level. All of the 3 other end bearings were inspected and were perfect.
We have been remapping cars for almost 8 years now and we have never known an engine failure directly related to a remap.
Obviously, we feel bad for Naresh having to pay for a new engine, but we cannot be held responsible given the circumstances.
Finally, we are certainly not "cowboys"... we have applied the same parameters to many 2.0 TDI CR's before the Tiguan and have done since without issue.
Is the user who drove the car before it was properly lubricated, a failure in the lubrication system or bad oil?
Did anyone check the oil that was put in at last service was correct for the engine.
Good to hear that the tuner has done the right thing in getting it all independently assessed and agree that the tune can't be held responsible for that type of failure.
The bellow is only my speculations, so don't take it as the VW service centers are like that. I believe that they have their young mechanics properly supervised.
Could the service centre forgot to put the oil in the engine when servicing the car, then realized that after starting and running the engine for who knows how long, then put the oil in ....checked everything and when all seemed ok, happily return the car to customer without saying a word?
It could be as simple as that, and it can happen when someone employs the young untrained people working on the cars.
It certainly happens to DIY car owners, from time to time I receive the phone calls for help after they've done some silly things when trying to save money doing their own home servicing.
The bellow is only my speculations, so don't take it as the VW service centers are like that. I believe that they have their young mechanics properly supervised.
Could the service centre forgot to put the oil in the engine when servicing the car, then realized that after starting and running the engine for who knows how long, then put the oil in ....checked everything and when all seemed ok, happily return the car to customer without saying a word?
It could be as simple as that, and it can happen when someone employs the young untrained people working on the cars.
It certainly happens to DIY car owners, from time to time I receive the phone calls for help after they've done some silly things when trying to save money doing their own home servicing.
Wow what an interesting read.
As an experienced diesel mechanic who worked for a main dealer, I read with interest each page of this thread, and the lack of co-operation by the main dealer doesn't suprise me. Things have changed a lot since I went through my apprenticeship, then there were more qualified mechanics than apprentices, now a limited number of mechanics in a main dealership, but numerous labourers and apprentices. Mistakes can easily be made, because even in my time, it was the "lads" who completed the remedial work.
What has been stated before, the photos show it was more likely a starvation of oil that would cause this, rather than a tune. I could understand even how a massive increase in bhp could cause a failure to an older worn engine, but very unlikely to something with only 20,000 on the clock.
VW never proved the map caused the problem via any written report, and also by what I read never really gave a reason for such a failure in a virtually new engine, as diesels are good for 100,000+ before damage like this could be experienced. It seems they have just said they will not cover because a map exists, but surely thay have to prove the map caused the problem before voiding the warrantee?
I understand the OP was in a situation, and hindsight is great, but the fact has to be taken into account, that it was that dealership that serviced the vehicle not long before the failure. It is a shame it could not have been taken to another mechanic for review, because maybe an independent opinion would have then been gained.
Just so everyone is clear about the situation, (because there is some pretty slanderous stuff in this thread), here is our version of events following the remap which we carried out on the Tiguan...
Initially we were shocked to find out that number 4 big end bearing had failed on Naresh's car, so we started our own investigations. The exact remapping file used was sent to two independent remapping companies (who actually make their own software), who said that the remap was acceptable and could not have caused damage.
We then employed a highly regarded Independent Auto Engineer (who has done this sort of thing most of his life) to go and inspect the engine at VW, ascertain why the engine failed and produce a report stating his findings.
His conclusions state that number 4 big end bearing suffered from a momentary lack of lubrication, and the bearing shell spun inside the con rod. Because number 4 bearing is the furthest away from the oil pump, it is likely that the engine had been starved of oil OR driven before the oil pressure had reached an adequate level. All of the 3 other end bearings were inspected and were perfect.
We have been remapping cars for almost 8 years now and we have never known an engine failure directly related to a remap.
Obviously, we feel bad for Naresh having to pay for a new engine, but we cannot be held responsible given the circumstances.
Finally, we are certainly not "cowboys"... we have applied the same parameters to many 2.0 TDI CR's before the Tiguan and have done since without issue.
Kind regards,
Mike.
More-BHP Ltd.
Good on you for jumping on here and explaining the situation, also good job on getting your own independent assessment done but seems that over there as it is here, VAG don't take that as proof that something could have been their fault. Did you also happen to consult with Naresh as to the results of your findings? This is relevant because the dealership and seemingly VW uk have taken the immediate stance of the tune being at fault. If this was mentioned whatsoever by any VW representative thn you will have grounds (both naresh and also your business potentially for defamation) to take to court.
I just hope your civil tribunals over there aren't as clogged up as ours because I people contesting speeding fines
Well the car is back in my garage now and I had to pay out for the repair myself. Birmingham VW here in the UK refused to cover the repair under warranty and also refused to blame the remap either so I was left asking myself who was actually to blame
In fairness to the dealer, their hands were almost certainly tied. Since last year, VAG have implemented changes in the scanning process whereby any remap (even if returned to stock) is automatically detected and a TD1 flag is added to the vehicle warranty record without any intervention by the dealer or the technician performing a service. It is completely transparent and the only way you can avoid getting this flag is to either never remap the car or never visit a dealer. Once that TD1 flag is added to your vehicle record, whether a power and drive train warranty claim is honoured is no longer up to the dealer. Whilst the dealer could argue as long as they liked that a remap did not cause a bearing failure, once that TD1 record exists they really have very little ability to pursuade VAG to pay up.
As for the reasons for VAG doing this, it is a deliberate crackdown on aftermarket remappings which are specifically mentioned (at least in Australia) as automatically voiding the warranty.
Given that most remaps are likely to be perfectly safe so long as good quality fuel is used, the car regularly serviced, properly driven, etc, on the other hand I can see the manufacturer viewpoint as well. They have to make a product that suits the mass market and they need to make it as durable and bullet proof as possible. The manufacturer cant predict or know that some owners will treat their vehicles in one particular way and that others will abuse their cars. So they have to shoot for a lowest common denominator (which is obviously pretty low given how well companies like DNA can improve the engine tune).
I would have thought that these days it would be possible to tell if a car had been abused or the engine stressed beyond safe limits by downloading data held in ECU memory, but perhaps things are not yet that sophisticated.
MY13 Polo 77TSI manual transmission Comfortline in Candy White - "Herr Marco"
I'm sorry for your troubles as a fairly ordinary car owner. If I'd had the sort of issues you were facing I have no idea how I would deal with it (I'd want to be rational and patient, but its a lot of money any which way and you still need to get around).
Its a shame that VW has taken to the blanket argument of 'if its tuned then they broke it' without having to back that up. Also, with the modern computer management, its harder and harder for independent dealerships to keep up to date with the ability to service the electrical components of these vehicles.
From the little evidence presented, it looks like VW have made an effort to not fully test and come clean, then again I don't know what contract you sign when you buy a new vehicle, maybe you signed a document saying that VW's word is final and that they decide the rules on the fly.
Shame, a new car with stock mechanical and a tune should be a joy, unfortunately we have to talk to VW with our wallets and encourage them to support our communities rather than pretending that VW's are so amazingly different than any other vehicle that you have to put fluids in with a VW sticker on them, serviced at a dealership (overcharged in many cases) and then be grateful that they continue to work on it if you decide to modify it in the slightest. One more reason I doubt I'd ever buy a modern VW.
In this case it would appear that no one at VW looked at the code, no one checked the oil was correct, no one asked how the ECU could cause a failiure in 1 cyl and not the other 3 and all in such a brief period. Seems to me like they didn't really want to get to the bottom of it, just get to the point they could show damage (anything really).
Ass-covering. After all this, will you keep it?
If this were in Aus, I'm guessing the bill would have been well north of $10k.
In response to what I have read from the above tuner I feel the need to clarify a few points and let others know where I stand on the matter. Until any evidence has been presented to me no one has yet escaped any blame. As a customer who paid for a service I'm not to blame here which is what it has felt like at times. In terms of driving style that shouldn't really doesn't apply to me as the car is/was used regularly for school runs transporting a 6 year old to school so any possibility of thrashing it around before the oil pressure/temperature was correct doesn't apply here. I certainly didn't buy an SUV to abuse on the roads. The remap was purchased to help open the car up a little so that overtaking on motorways/highways became easier, as I felt the diesel engine (my first) ran out of puff far too easily for my liking.
As for this so called report suggesting that number 4 piston failed, well I have yet to see any evidence of this report whatsover. If it exists, then apologies are due, but until then the fact that Mike, Jason, or whoever is in charge at "more-bhp" stating that they had an independent, highly regarded, auto engineer inspect my car is simply lip service and a whole PR stunt. In fact, that statement has more holes in it than a lump of swiss cheese. However, I will re-iterate my first statement - if the report exists then the tuner has my contact details and as I have requested several times before via email, I am happy for them to furnish me with their evidence so that I can take that to the UK dealer to prove that the remap wasn't at fault.
I've also not seen any evidence of any investigation of the mapping software placed on my car. If that took place I was certainly not told who carried it out, despite asking for that report.
It may seem harsh to the tuner that I have chosen to write here about my problems but I did ask them for the report and the details listed above regarding big end bearing on number 4 piston and the lack of lubrication, oil startvation etc has only now been mentioned when I have spoken about them publically. Coincidence? Perhaps. Covering their backs? Very likely? Being in the tuning business for 8 odd years is no excuse. Everyone makes mistakes and the wrong ignition timings, not checking vehicle components before mapping, or any other aspect of tuning, no one can escape blame until hard physical evidence can be presented to me. For me, this whole experience has left me both mentally and physically drained, and came at a time when my wife was recovering from an unplanned hysterectomy. The last thing we all wanted was additional stress and strain in our lives.
The fact is now that I am left with a £5,500 debt that I shouldn't have paid out for. Both VW and the tuner has washed their hands of it from the very start. VW immediately voided my warranty and my emails to the tuner were simply met with replies of internet links to their terms and conditions page stating no warranty on modified vehicles. All work on my car was carried out with no communication to myself despite constant messages being left with them and the map was removed from my car during that process without me knowing. It was only when a rare call from the dealer told me that more-bhp had travelled down to them to remove my ECU to take back to their workshop that I was aware of this. When I was told initially that returning the car to stock would lead to a refund of the cost I received no contact from the tuner telling me that he had removed my map and I was due my money back. It was only when I called him that he reluctantly refunded it. Obviously that cost was peanuts to what I have shelled out on the repair so hardly a goodwill gesture of any kind!
No one should be put in this position after a remap, a new engine after 20,000 miles and the heartache of being hit in the wallet so hard that you are physically sick to the pit of your stomach!
Until someone puts up their hand to say they were at fault, or I receive some actual real evidence this saga won't end until I get some closure and that may be harsh on the tuner but if you were to spend at least a day in my shoes you could actually empathise what I have been through. Up to now it all seems like one big conspiracy with the tuner and dealer making an "apparent" agreement to keep quiet so they can both continue with their daily business with no apparent guilt being shown. The service manager at VW certainly benefitted financially from this whole event!
2011 Candy White Tiguan R Line 170 TDI DSG | Pan roof | Park assist & RVC | RNS 510 | MDI | LED's | 20" RS5 Wheels| Bi-xenons & AFS | Front & Rear footwell lights | Door warning & puddle lights | Mirror puddle lights | LED Tail lamps | Eibach Pro-Kit Springs
Comment