New Polo problems - Register

[luvpsi]

Hi all, hope this is the right place to post this.

I own a MY13.5 Polo GTI with a panoramic sunroof, which has been making noise when the body/roof is flexing (ie when entering driveways etc..) Have taken it back twice, each time they 'greased' it however the noise returns each time.

Recently I have noticed that when left out in sun for a while (on 30deg plus days) the roof becomes very noisy even when driving on flat roads?? has anyone else had this happen?

I also have a rough Idle on cold start up, and the engine sounds sort of like there is a manifold leak for about 5-10 secs, idle is a little shaky and sometimes emits blackish smoke..

Final thing (just noticed this morning), there seems to be a slight 'jerk' or 'shudder' when shifting into 3rd gear via manual mode..

Car has only covered 14,000kms

if anyone has experienced this and can share some info on any of these that would be great

[Harrydhillon]

Hi all, hope this is the right place to post this.

I own a MY13.5 Polo GTI with a panoramic sunroof, which has been making noise when the body/roof is flexing (ie when entering driveways etc..) Have taken it back twice, each time they 'greased' it however the noise returns each time.

Recently I have noticed that when left out in sun for a while (on 30deg plus days) the roof becomes very noisy even when driving on flat roads?? has anyone else had this happen?

I also have a rough Idle on cold start up, and the engine sounds sort of like there is a manifold leak for about 5-10 secs, idle is a little shaky and sometimes emits blackish smoke..

Final thing (just noticed this morning), there seems to be a slight 'jerk' or 'shudder' when shifting into 3rd gear via manual mode..

Car has only covered 14,000kms

if anyone has experienced this and can share some info on any of these that would be great

I have the same issue with creeky noise and the sun roof rattle... Haven't noticed the rough start...

[nomadx38]

Don't know if this constitutes as a problem but I didn't really want to open a new thread for this.

Since Wednesday I have noticed I have a film of clear oil (or oily substance - almost like silicon spray) on my exhaust tip. I saw it Wednesday and decided to clean it down and now checking today again it's back. No soot, just oily - and clear, so I'm not even sure that its engine oil - oil level from what I can see is unchanged so I'm not sure it's been burning it.

Engine has been running rich and 200rpm above normal due to the hot weather but I have seen this before and I consider it normal - but I have never seen the oil.

Now for those that don't know it's been a constant 40deg since Monday here in Melbourne - which could be the reason.

Anyone else notice this on their car recently, I would be interested to hear about it.

[alexaescht]

Uh oh!

[nomadx38]

Uh oh!

VCDS - you gota get on that

[alexaescht]

VCDS - you gota get on that

I'll just let VW muck around with it tomorrow

[alexaescht]

Booked in for this Thursday to look at the warning light, and to look at the front suspension, steering wheel, air con, DPF and bearings. Yay.

[TSI_Dan]

My mother drives a 2013 Polo Trendline manual with about 2,400km and it has developed a cold starting problem. Takes 3 or 4 goes before it finally kicks over and then runs extremely rough for between 5-10 sec with low RPM, sounds like it's misfiring. Only seems to happen on mornings parked on the street, once it dips below around 15 degrees. This leads me to think perhaps a sensor as it is perfect once warm, or even after restarting after the initial cold start. Leads? Plugs? Coils? ECU?

Annoyingly VW have brushed her off with the standard "oh many 1.4 Polos do that, common problem, we have forwarded on the diagnostics and don't have a fix yet". Any ideas or anyone experienced a similar issue?

[nomadx38]

My mother drives a 2013 Polo Trendline manual with about 2,400km and it has developed a cold starting problem. Takes 3 or 4 goes before it finally kicks over and then runs extremely rough for between 5-10 sec with low RPM, sounds like it's misfiring. Only seems to happen on mornings parked on the street, once it dips below around 15 degrees. This leads me to think perhaps a sensor as it is perfect once warm, or even after restarting after the initial cold start. Leads? Plugs? Coils? ECU?

Annoyingly VW have brushed her off with the standard "oh many 1.4 Polos do that, common problem, we have forwarded on the diagnostics and don't have a fix yet". Any ideas or anyone experienced a similar issue?

Lol it seams they use the "it's normal" approach on everything these days.

I'm pretty sure this NA 1.4L engine is as old as the hills, there is nothing new/complex in them that has been added recently so one would assume all the bugs were worked out a very long time ago - If any, seriously how complex can a MPEFI naturally aspirated engine get haha

Now I would look at the ignition system - leads if it has any (but I have a feeling its using direct acting coil-on-plugs). If it is using leads check each one for resistance (ohms) on a multimeter.

They should all be about the same values.

I would also check the battery terminals to see if they are clean and tight.

It could also have a poor fuel pump (tank side) but honestly I'm not sure how you could test this unless there was a drain valve coming off the common fuel rail (like some fords) which you could use to see if fuel is in the fuel line.

VCDS might be a good place to check though if you have it handy.

[alexaescht]

Picked the Polo up today from VW. The check engine light was to do with the exhaust pressure sensor that had failed, the oil smell during DPF regeneration was to do with the oil pipe from under the turbo coming loose and dripping oil onto the DPF (they said "someone must have fiddled with it at some point." Yeah, maybe when you replaced the EGR valve...)
They couldn't fault the suspension, even after driving it for "ages." They said the air conditioning couldn't be faulted, and finally, they said the the reason the steering wheel isn't straight is because the car needs a wheel alignment. I thought that wheel alignments weren't possible on Polo's? Correct me if I'm wrong...

Alex.

[Guest001]

Picked the Polo up today from VW. The check engine light was to do with the exhaust pressure sensor that had failed, the oil smell during DPF regeneration was to do with the oil pipe from under the turbo coming loose and dripping oil onto the DPF (they said "someone must have fiddled with it at some point." Yeah, maybe when you replaced the EGR valve...)
They couldn't fault the suspension, even after driving it for "ages." They said the air conditioning couldn't be faulted, and finally, they said the the reason the steering wheel isn't straight is because the car needs a wheel alignment. I thought that wheel alignments weren't possible on Polo's? Correct me if I'm wrong...

Alex.

Alignment on front Not on rear Just had the Stealer tell me mine was due for a 4 wheel alignment I asked if I could watch while they do the rears LOL

[nomadx38]

Picked the Polo up today from VW. The check engine light was to do with the exhaust pressure sensor that had failed, the oil smell during DPF regeneration was to do with the oil pipe from under the turbo coming loose and dripping oil onto the DPF (they said "someone must have fiddled with it at some point." Yeah, maybe when you replaced the EGR valve...)
They couldn't fault the suspension, even after driving it for "ages." They said the air conditioning couldn't be faulted, and finally, they said the the reason the steering wheel isn't straight is because the car needs a wheel alignment. I thought that wheel alignments weren't possible on Polo's? Correct me if I'm wrong...

Alex.

Wheel alignments can be done on the Polo's BUT make sure you do a front alignment only and get charged appropriately (55$ from bob jane). Only toe in/out can be adjusted on the front (Pretty sure camber is fixed) and the rear is 100% fixed.

Also don't forget to tell them to centre the wheel once It's aligned.

And yeah I just laugh at them when they ask me if I want a 4 wheel alignment. The first time I went to get my wheels aligned (not from the stealership) they knew straight away that you can only do the fronts - and the stealership apparently still doesn't know this...

[alexaescht]

Alignment on front Not on rear Just had the Stealer tell me mine was due for a 4 wheel alignment I asked if I could watch while they do the rears LOL

Haha their reaction to that would've been something to see.

Wheel alignments can be done on the Polo's BUT make sure you do a front alignment only and get changed appropriately (55$ from bob jane). Only toe in/out can be adjusted on the front (Pretty sure camber is fixed) and the rear is 100% fixed.

Also don't forget to tell them to centre the wheel once It's aligned.

And yeah I just laugh at them when they ask me if I want a 4 wheel alignment. The first time I went to get my wheels aligned (not from the stealership) they knew straight away that you can only do the fronts - and the stealership apparently still doesn't know this...

I'm definitely not going to get it done at the dealer. lol.

Thanks for the tips

[LukePolo]

Haha their reaction to that would've been something to see.



I'm definitely not going to get it done at the dealer. lol.

Thanks for the tips

I really should have read this BEFORE I had the front + rear alignment done for $120 at Trivett Blacktown..............

[nomadx38]

I really should have read this BEFORE I had the front + rear alignment done for $120 at Trivett Blacktown..............

Ouch! To add insult to injury that is one very expensive 4 wheel alignment.