lightened flywheel ?? clutch advise??

[ontarv]

should i lighten my flywheel motor is fairly worked
as is in other thread
but is there much to be gained by taking a third
or quarter off the weight
and where is the best place to get a 200 mm clutch kit
from and is there more than one type in that size
already ordered wrong one once thought it was a 210mm
they might not be so nice if i order the wrong one again
thanks

[gumbootracing]

Depends on wether you want torque or acceleration a lightened flywheel will pickup rpm quicker but because the rotating mass will be less therefore less stored energy ergo less tourque we pulled a heap of weight from the flywheel of another car we own and revs out much better but you use the gearbox much more with a car already modified to rev harder I would simply clean up the flywheel and get it balanced
Cheers T

[Golf Loon]

should i lighten my flywheel motor is fairly worked
as is in other thread
but is there much to be gained by taking a third
or quarter off the weight
and where is the best place to get a 200 mm clutch kit
from and is there more than one type in that size
already ordered wrong one once thought it was a 210mm
they might not be so nice if i order the wrong one again
thanks

1.6 is 190mm GTI Is 210mm
I think 200 must be a Diesel
There was a new clutch kit for 200mm on Ebay recently, check the completed listings.
I`d change the flywheel and put the common 210mm clutch on it

[gldgti]

diesel is 190 also...

[h100vw]

I reckon the 210 is 1800 GTI. The 200 I think is 1600 GTI and 190 for everything else. Could of course be talking rubbish!!
Gavin

[aprr32]

clutch

200mm is 1500 dsl in Australia.

[ontarv]

thanks for the advice
my old clutch was 180mm by the tape
and ended up rather purple, flywheel as well
makes sence that it would be a diesel flywheel
its has a lot weight to it than the old one
not long brought this flywheel was ment to be 210 mm
but i'll as long as it holds a bit better than old clutch
i'll be happy and also funds are short
was thinking of balancing as well, as old one was
so i will lighten it i bit and balance
thanks guy's

[Golf Loon]

Buy This

http://cgi.ebay.com.au/Vw-Volkswagen-golf-passat-clutch-plate-200ml-sachs_W0QQitemZ290086627388QQihZ019QQcategoryZ72456QQrdZ1QQcmdZViewItem

He also has the pressure plate in another auction

[ontarv]

thanks loon your a legend!!!
just messaged him to see if pressure plate
had center and clip
cause it wouldn't be the same as smaller clutch
would it??

[golfnutracing]

A mate of mine took the standard flywheel, had it turned out to a larger diameter (i think 200mm) and threw the big clutch in it, you lose your little alignment nobs, but you get a light flywheel and a big clutch cheap cheap.

[gldgti]

200mm is 1500 dsl in Australia.

i've changed out a few 1500 diesel clutches and they all seem to be 190 mm. i just put a petrol golf one back in my diesel and that works just fine too...

[ontarv]

got clutch

yay one clutch plate & pressure plate off
the bay cheap too
I'm stoked!!!!

[ontarv]

just got flywheel back resurfaced
and balanced yay!!
hopefully have all runing in a couple of weeks